Get a FREE Issue of Earth Island Journal
Sign up for our no-risk offer today.

Go Back: Home > Earth Island Journal > Latest News > Post and Comments

Latest News

Tar Sands Oil Ain’t Jed Clampett’s Bubblin’ Crude

Three years later, Kalamazoo River pipeline spill an omen as industry grows

Sue Connolly knew immediately that something was terribly wrong. On July 26, 2010, the resident of Marshall, a town of 7,400 in southwestern Michigan, awoke to a burning sensation in her eyes and throat that made her and her family sick.

“There was a strong odor in the air that took your breath away,” Connolly recalls. “If you tried to take a deep breath, you would feel it all the way down to your stomach. Migraine headaches, lethargy and diarrhea followed.”

Connolly and her neighbors were among the first witnesses to the Kalamazoo River oil spill – a massive pipeline rupture that dumped nearly one million gallons of crude into Talmadge Creek, which feeds the Kalamazoo River – the largest and most expensive on-land oil spill in U.S. history. The water level was high that week, and a black goo quickly covered the banks and the flood plains on either side of the river. Authorities initially feared that the spill could reach Lake Michigan 115 miles downstream.

The spill was caused by a six-and-a-half foot gash in Line 6B, a 30-inch carbon steel pipeline operated by Enbridge, Canada’s largest transporter of crude oil. Alarms had sounded the previous evening at an Enbridge control room 1,500 miles away in Edmonton, Alberta, but the warnings were ignored. Convinced that low oil pressure in the pipes near Marshall indicated an air bubble, Enbridge engineers ignored the alarms and continued pumping oil. It wasn’t until 11:17 the following morning that a Michigan utility company employee called Enbridge’s emergency number to report that oil was gushing into the creek. By that time, Connolly was already aware that a disaster was underway. But local residents and first responders were both woefully unprepared.

“When the spill happened, we got a call that there was oil that had went into the Talmadge Creek, and we expected to see an overturned truck or something like that,” says Jay Wesley, natural resource manager with the Michigan Department of Natural Resources (MDNR). “Half the river was black. For us here in Michigan, we never thought we were an oil state. My staff had never been trained for this type of event.”

“We had plans for tornados and even terrorists, but we never had a plan for an oil release,” echoed Paul Makowski of the Calhoun County Health Department.

Unbeknownst to citizens in Marshall, Enbridge was pumping diluted bitumen, or “dil-bit”, through its 293-mile pipeline in southern Michigan. That’s the same kind of oil as Tar Sands crude that comes from Alberta, Canada. It is fracked out of the bedrock, and then chemicals are added to the gooey, peanut butter-like substance to make it viscous and capable of being pumped through a pipeline. Line 6B is part of Enbridge’s Lakehead system, which transports Canadian crude to refining stations in the Midwest and Ontario.  

But when an oil spill happens, the bitumen crude separates from the chemicals. The oil becomes heavy and sinks, and harmful chemicals like benzene are released into the air. Those chemicals sickened Sue Connolly’s family, and hundreds in Marshall.

Three years after the Kalamazoo River spill, this tragedy holds important warning signs for communities and municipal and state governments. Oil pipelines now crisscross the entire country, running through Midwestern states that are not oil producers but have become oil transit zones. Many of them already carry Canadian Tar Sands oil.

photo of a man holding a tutle near a fouled watercoursephoto by U.S. Fish and Wildlife Service, Midwest Region, on FlickrMap turtle released in Wilder Creek after being stabilized and cleaned.

The July 6 disaster in Quebec, when a runaway train carrying oil blew up much of the town of Lac Megantic, highlights the perils of transporting oil by rail too. The country has entered a new and dangerous phase, as we confront new fossil fuels, new ways to get them, and determine how to safely transport them.

“The industry in Canada plans to triple production by 2030,” says Josh Mogerman, a spokesperson with the Natural Resources Defense Council (NRDC). “Folks who are concerned about climate issues are concerned about these production numbers. That’s part of the reason why you’ve seen such an uproar over Keystone XL.”

Environmentalists are frenetically pressuring the White House to reject the proposed Keystone XL pipeline, which would carry Tar Sands oil from Alberta to refineries in the Gulf of Mexico, and across the Ogallala aquifer, which supplies drinking water for eight Great Plains states and 30 percent of the nation’s irrigation water. Meanwhile, in Michigan, environmentalists are also worried about an Enbridge pipeline that runs underwater through the straits of Mackinac.

“All across the state of Michigan and all across the Great Lakes basin, pipelines are being expanded,” says Beth Wallace, community outreach coordinator with the National Wildlife Federation (NWF) and a native of Marshall. “This ultimately makes the Midwest the hub for the transportation of Tar Sands and refining.”

A spill in the Mackinac Straits could dump hundreds of thousands of gallons of oil directly into Lake Michigan and Lake Huron in the heart of the world’s largest freshwater resource. A July 14 protest at the famed Mackinac Bridge sought to hold Enbridge accountable. The rally, keynoted by environmental leader Bill McKibben, was organized by advocacy groups including 350.org, the National Wildlife Federation and the Michigan Land Use Institute.

“The good news is that we have the technology we need to stop using fossil fuels,” 350.org founder McKibben told approximately 400 concerned attendees. “And I see our movement rising everywhere now. If we manage to stop (global) warming, you will have done the most important thing you could ever possibly do. What happens over the next 10 years will determine what happens to us over the next 10,000.”

Rally organizers sported an online petition pressing Michigan Gov. Rick Snyder to demand better protection for the Great Lakes from the pipeline which daily carries almost 22 million gallons of oil and gas from Superior, Wis., to refineries in Sarnia, Ontario. Enbridge’s Line 5 flows through pipes on the lake floor and passes near many inland lakes and streams.

Organizers also called on Enbridge to replace Line 5 with modern piping and sensor technology and permanently ban its use for Tar Sands oil, which, as the Kalamazoo River spill demonstrated, is more difficult to clean up. Enbridge maintains that it has no plans to ship dil-bit crude through the Mackinac Straits, but Wallace, who spoke at the July 14 rally and who co-authored NWF reports on the Kalamazoo River spill and on the risks of Line 5, urged rally-goers to be skeptical of the global pipeline giant’s claims. “Enbridge must be held to the highest possible standards by the Environmental Protection Agency and PHMSA (the U.S. Department of Transportation’s Pipeline and Hazardous Materials Safety Administration). The company must agree to no Tar Sands, ever, through this pipeline.”

NRDC and other advocacy groups published a report in 2011, which showed that heavy Tar Sands oil corrodes pipelines much quicker than conventional crude does. In fact, Canadian pipelines transporting dil-bit have ruptured 16 times more often than American pipelines carrying traditional crude, even though Canada’s pipelines are much newer.

“Usually, when we think of oil, we think of (“The Beverly Hillbillies”) Jed Clampett going out and up from the ground comes bubblin’ crude,” says Mogerman. “You see pictures of the old gushers in California. But this is fundamentally different from that. This petroleum is either strip-mined or steamed out of the ground. Diluted-bitumen requires significantly more pressure to move this heavy, sludgy stuff through the pipeline. They also operate at a higher temperature. Dil-bit is very high in sulfur, which contributions to corrosion, and it is more highly acidic than typical petroleum.”

But the oil industry claims that Tar Sands oil poses no greater risk to pipelines than conventional crude does. A report released in June by the National Research Council, a 12-member committee of technical experts and scientists, corroborates the industry’s position, stating that “diluted bitumen does not have unique or extreme properties that make it more likely than other crude oils to cause internal damage to transmission pipelines from corrosion or erosion.”

According to Enbridge, it wasn’t heavily diluted bitumen that caused the Kalamazoo River spill, but faulty coating on the outside of the pipeline. Company spokesperson Jason Manshum says that the old coating, which was one-quarter of an inch thick and wrapped around the pipeline in the 1960s, has been replaced by fusion bonded epoxy coating 0.375 inches thick.

In early May, Manshum spoke to fellows with the Institutes for Journalism and Natural Resources (IJNR) who were reporting on the oil spill. At Enbridge’s Kalamazoo office, he performed a show-and-tell routine with six different oil samples. What he claimed was the capsule of diluted bitumen sounded just like water when he shook it, ostensibly implying that it was no less viscous than the others.

“I want you to listen to this; that’s a pure liquid,” says Manshum. “All of the sand and the clay that could be abrasive are extracted before it ever gets in the pipeline. We could not ship a product through our terminals, storage facilities and pump stations if there was something abrasive in them. It would be like if you fueled up your lawnmower and you had sand in your gasoline. Would your lawnmower run for very long? No, it would probably break down.”

After the Kalamazoo River spill, local environment and municipal officials were surprised that the oil didn’t remain on the surface but began to sink to the bottom and coat riverbank vegetation and wildlife. It took about a week for Enbridge to reveal that diluted bitumen was involved. Officials and first responders eventually figured it out for themselves.

“This oil was heavy to begin with,” explains Ralph Dollhopf, incident commander with the Environmental Protection Agency. “Certain components of this oil began to volatilize, making an already heavy oil even heavier. It was clear to us that there were volatilization issues associated with the oil. My recollection was that within the first week to week-and-a-half, they told us that dil-bit was involved.”

The byproduct of the Tar Sands oil was the benzene that escaped into the air and posed a health risk to nearby residents and first responders.

“We were very naïve about the health effects of the oil, especially the benzene,” said MDNR’s Wesley. “Our crews naturally wanted to get on the river immediately and start working. But they had to be held back.”

Remarkably, three years later, Talmadge Creek, which was Ground Zero for the spill, and the Kalamazoo River itself, have largely recovered. The aquatic ecosystem looks clean, save for the occasional oil-marked tree. And fish and wildlife have returned. After Enbridge’s initial omission to report the type of oil that spilled, the company has received praise from local officials for its cleanup effort.

IJNR journalists who paddled the river in May found scant evidence of remaining oil. But the EPA’s Dollhopf said that small sheens or globules of oil do appear on warm days, particularly when the riverbed is disturbed by currents or a canoe paddle.

Nevertheless, Marshall residents aren’t out of danger yet. Claiming it needs to upgrade the pipeline coating, and citing growing demand for its product, Enbridge is building a new 280-mile pipeline, parallel with the current one. Local citizens, through whose backyards the current and new pipeline will run, are worried about future oil spills.

“They’re curving the new pipeline (easement) around our house,” says Dave Gallagher, whose home sits mere feet from the current pipeline. “Pumping oil at that kind of pressure, what’s that going to do with the pipe? … The heat that’s generated from these pipes helps melt the snow in the,” adds Gallagher, who worries what the pipeline proximity will do to the resale value of his home.

“Enbridge dealt poorly with individual landowners, they have been dismissive of local municipalities, and they have been stubborn when it came to the regulatory process here in Michigan,” says Jeff Insko, who started the “Line 6B blog” to inform local citizens about Enbridge’s intentions.

Feeling as though they’ve been bullied by Enbridge, landowners such as Insko and Sue Connolly say that the biggest asset they have is each other. Citizens like them will be on the front lines if another oil spill happens.

“The first people who are going to know about a pipeline spill are the residents that live here,” says Connolly, whose daughter developed a strange rash three days after the oil spill. “It’s not gonna be the pipeline company, it’s not gonna be your first responders, it’s gonna be us.”

While it is employing newer and better technology, Enbridge can’t unequivocally guarantee that another oil spill won’t happen, either in the Kalamazoo River or in the Straits of Mackinac.

“We’re clearly not yet there,” says Manshum. But we’re putting all the pieces in place to minimize the risk of any leaks. Much like I can’t get on an airline at Detroit Metro Airport and be assured there won’t be any mechanical trouble or that the plane won’t crash. But I can tell you that many procedures have changed internally, and externally as well, to minimize that risk.”

Those words aren’t good enough for environmental advocates like the NRDC’s Josh Mogerman.

“We need to know how to move this stuff safely,” says Mogerman. “We need to study and know if this stuff requires additional and different infrastructure to move it safely.”

Reporting for this story was made possible in part by a fellowship from the Institute for Journalism & Natural Resources. This story appears concurrently on TheUpTake.org and the Glen Arbor Sun newspaper.

Email this post to a friend.

Write to the editor about this post.

Subscribe Today
cover thumbnail EIJ cover thumbnail EIJ cover thumbnail EIJ cover thumbnail EIJFour issues of the award-winning
Earth Island Journal for only $10

 

Comments

Great piece, Jacob Wheeler! The Line 6B Citizens’ Blog is here: http://grangehallpress.com/Enbridgeblog

By Jeff Insko on Thu, July 25, 2013 at 1:12 pm

Leave a comment

Comments Policy

Remember my personal information?

Notify me of follow-up comments?

Please enter the word you see in the image below:

View Posts by Date View Posts by Author

Subscribe
Today

Four issues for just
$10 a year.

cover thumbnail EIJ

Join Now!

 
Go Solar with Earth Island Institute!

1.2105